[Jukebox-list] Wurly 2410 repeats same record

[etreble7]

Hi Ron,
I just happened to have this great "oiler" that I got from a friend and it 
reaches all the crazy places.  I found 2 oil holes, one on the top and one 
on the bottom.  I oiled them really well (being careful not to let any drip 
on the switches) and then played the machine for about 2 hours.  This 
morning I got up and did it again.  Hopefully you have saved it from burning 
up, many thanks!

I checked the cable for the needle brush, it was on the pulleys but the 
brush arm was a little stiff, so I cleaned it and then oiled that.  It moves 
much smoother now.  I am hoping these things may take care of the transfer 
switch issue.  It seems to be working well now.  I appreciate all your help,
Jackie

----- Original Message ----- 
From: "Ron Rich" <ronnnrich at yahoo.com>
To: "Jukebox mailing list" <jukebox-list at lists.netlojix.com>
Sent: Thursday, September 06, 2007 12:26 AM
Subject: Re: [Jukebox-list] Wurly 2410 repeats same record


> Jackie,
>  Smoke ainta no good---Is that motor an "open" or "closed" type? If there 
> is an oil hole on it , oil it now.
>  As for the cable attached to the brush--check that it is on the 
> pulleys-not jamming behind one, and that the needle brush is adjusted so 
> that the tip of the bristles just touches the tip of the needle as it 
> passes by. Also, on some model Wurlys, the pivot point that the brush arm 
> turns, on gets gummy-clean and oil it.
>  Ron
>
> etreble7 <etreble7 at verizon.net> wrote:
>  Hi Jim,
> many thanks, you were right on! It was the transfer switch. I am not sure
> why it's acting up, but I messed with the cable attached to the brush and
> manually moved the blade over so the spring would snap and then tried
> another record. It canceled out just fine.
>
> I do however have another issue I noticed, the transfer is running very
> slow, the arm goes up very slow or comes down slow, then the record clamps
> and it runs up to speed. I also noticed a small amount of smoke coming 
> from
> what seemed to be the motor up by the transfer switch before it started
> working again.Any idea what could cause that?
>
> Also, Ron, thank you also for the reminder about the pawl. The one on the
> right (from the back of the machine) was all gummed up with oil. I'm
> puzzled as to how it got there because I cleaned those completely with
> alcohol not long ago and they were clicking, clean as a whistle. I wiped 
> it
> off again, the one on the left seemed fine.
>
> Everytime these Jukeboxes run, I am still amazed. I hope I never loose 
> that
> thrill, it's just so much fun! Thank you all so much,
> Jackie
> ----- Original Message ----- 
> From:
> To: "Jukebox mailing list"
> Sent: Wednesday, September 05, 2007 7:09 PM
> Subject: Re: [Jukebox-list] Wurly 2410 repeats same record
>
>
>> If the pin is canceled, check the transfer switch - this is the "snap
>> acting" switch on the rear of the mech with the needle brush cable
>> attached. If it doesn't snap back at the end of the cycle, it will play
>> the same record over again. Make sure the mounting screws are tight 
>> before
>> turning the nylon-tipped adjusting screw. Good luck,
>>
>> Jim
>> ----- Original Message ----- 
>> From: "etreble7"
>> To:
>> Sent: Wednesday, September 05, 2007 1:42 PM
>> Subject: [Jukebox-list] Wurly 2410 repeats same record
>>
>>
>> Hi to everyone,
>> I feel I've been blessed that this Wurlitzer has been working great, so I
>> haven't had to post a question for a long time. So here goes... the same
>> record is being repeated. The pin is canceled but then the song is over
>> it rejects, returns the record to the basket and then picks it up
>> again....over and over. If you make another selection, the correct pin is
>> pulled but the magazine doesnt move, it just repeats the same record.
>>
>> Thanks for any help, it's much appreciated.
>> Jackie
>> _______________________________________________
>> Jukebox-list mailing list
>> Jukebox-list at lists.netlojix.com
>> http://lists.netlojix.com/mailman/listinfo/jukebox-list
>>
>>
>> _______________________________________________
>> Jukebox-list mailing list
>> Jukebox-list at lists.netlojix.com
>> http://lists.netlojix.com/mailman/listinfo/jukebox-list
>
> _______________________________________________
> Jukebox-list mailing list
> Jukebox-list at lists.netlojix.com
> http://lists.netlojix.com/mailman/listinfo/jukebox-list
>
>
>
> ---------------------------------
> Got a little couch potato?
> Check out fun summer activities for kids.
> _______________________________________________
> Jukebox-list mailing list
> Jukebox-list at lists.netlojix.com
> http://lists.netlojix.com/mailman/listinfo/jukebox-list